Volvos Issues Recall on S40, V50, S60 and XC60 Models Over Power Seat Problems

A defective front passenger seat power system on certain Volvo models has prompted a recall of 7,420 cars from the Swedish automaker. Federal officials said that the front seat rail's detection system was manufactured incorrectly and may permit the passenger to forward the seat beyond the intended maximum, putting them at risk of injury in a crash.

The models affected from the recall are the 2009-2011MY S40 sedan, V50 station wagon and S60 sedan, plus the 2010-2011MY XC60 crossover. Volvo said the company's dealers will inspect the front passenger side seat rails for the presence of an "end stop" and repair the vehicles as necessary free of charge.

The Swedish automaker has not yet provided a date for the scheduled recall, but owners can contact the company for more information at 1-800-458-1552.

By Csaba Daradics

_______________________________GALLERY_______________________________

Toyota to Voluntarily Fix 378,000 Prius Hybrids for Overheating Problems

Toyota's US division has issued what it describes as a "limited service campaign" (and not a recall…) on approximately 378,000 U.S-spec Prius hybrids from the 2004 and 2007 model years to resolve a potential problem with the water-pump that can cause the cars to overheat.

“The water pump is part of a system designed to cool the hybrid powertrain components and is separate from the engine cooling system” said John Hanson, Toyota Motor Sales National Manager of Environmental, Quality and Safety Communications. “A fault in the water pump can cause air bubbles to build up and disrupt the flow of coolant, which can lead to overheating”.

The company said an “on” check engine light can signal the problem. If the car is driven further the temperature of the hybrid components can reach a critical level and the vehicle will enter “fail-safe mode” to prevent damage.

Oddly enough, the Japanese automaker pointed out in a press statement that the issue is being treated as a "customer support campaign" and not a "recall" as the company "determined it is not a safety issue” and it “has not received any reports of accidents or injuries related to this condition."

Owners will be notified by mail in early December and Toyota dealers will replace the water-pump for free, as long as customers arrange for service before November 30, 2013. Clients who have had their water-pumps replaced because of this condition are going to be reimbursed.

For detailed information customers can call the Toyota Customer Experience Center at 1-888-270-9371.

By Csaba Daradics

Recall Alert for 3,000 Land Rover LR2 Freelanders

The U.S. National Highway Traffic Safety Administration has announced a new recall for certain 2010-2011MY Land Rover LR2 Freelanders built from November 12, 2009, through August 23, 2010. According to the safety agency, in the affected vehicles the driver's frontal airbag may not deploy as intended or at all because of a potential problem with the shorting bar in the clock spring, which may become disconnected when the air bag module connector is installed.

To fix the problem, the company said it will install a spacer into the driver's airbag clock spring harness connector. This service will be performed free of charge with the safety recall expected to begin on or before December 13, 2010. For more information, owners of the affected LR2s can contact Land Rover at 800-637-6837.

NHTSA Investigating Honda Accord Hybrid for Uncontrollable Acceleration

The National Highway Traffic Safety Administration [NHTSA] has opened up a preliminary investigation to review a claim from an owner of a 2005MY Honda Accord Hybrid who said that in 2005, she was involved in an accident after the car lost braking power subsequent to crossing over rumble strips, then accelerated uncontrollably.

According to the report, the car crashed into oncoming traffic and killed her passenger. The driver of the vehicle alleges the crash left her disabled while the occupants of two other vehicles were also injured.

The safety agency added that the petition identified 22 other complaints involving Honda Accord and Civic hybrids that the driver felt represented similar incidents where the braking performance was inadequate under conditions of braking while driving over uneven road surfaces.

The NHTSA said it will investigate the case and decided whether or not to issue a recall for the affected Honda Accords. Scroll down to read the full report from the safety agency.

NHTSA Release

A defect petition letter was received by the Office of Defects Investigation (ODI) requesting a formal investigation and recall of MY 2005 Honda Accord Hybrid vehicles for a possible safety defect related to braking performance. The petitioner (with assistance from another consumer due to her injuries) filed a complaint with ODI under Vehicle Owner Questionnaire (VOQ) 10329383.

In the complaint the petitioner described being involved in a crash on July 23, 2005 while driving a subject vehicle. Summarily, the complaint alleges while traversing rumble strips along side of the highway and simultaneously attempting to the brake, the brakes were ineffective and the vehicle began to accelerate uncontrollably.

This began a chain of events where the vehicle eventually crossed over into traffic flowing in the opposite direction. The end result was the death of her passenger and injuries to the occupants of two other vehicles. The petitioner also alleges the crash left her disabled.

Subsequent to the incident on July 23, 2005, the petitioner did a search of ODI's complaint database and identified 22 additional complaints involving other Honda Accord Hybrid and Honda Civic Hybrid vehicles that the petitioner felt represented similar incidents where the braking performance was inadequate under conditions of braking while driving over uneven road surfaces. ODI will evaluate the petition for a grant of deny decision.

_______________________________GALLERY_______________________________

GM Recalls 2010-2011 Cadillac DTS and Buick Lucerne Over Possible Fire Risk

If you happen to be one of the 13,780 owners of a 2010-2011 Cadillac DTS or Buick Lucerne sedan with a V8 engine, you'll soon receive a recall letter from General Motors. According to the National Highway Traffic Safety Administration [NHTSA], the aforementioned sedan models have alternator cables that can wear through a power steering line causing a fluid leak. The power steering leak could result in a loss of power steering as well as fall onto hot engine parts and cause an engine compartment fire.

Up until now, there have been two reports of fires in late August related to this problem.

To fix this issue, GM said dealers will secure and if necessary, reroute the lines to prevent contact. As expected, the service will be performed free of charge. The Detroit automaker will begin mailing letters to owners of the affected models on November 19.

_______________________________GALLERY_______________________________

Cadillac Recalling 2010MY SRX Crossover to Fix Power Steering Line

General Motors said on Thursday it is issuing a voluntary safety recall of 3,996 Cadillac SRX crossovers from the 2010 model year due to a possible damage to the power steering line. According to the company, if the line is damaged, power steering fluid could leak and make its way onto hot engine parts resulting in a fire. GM said it is aware of one such fire in an unattended SRX related to this condition.

"Based on GM analysis, the issue is believed to exist in only two or three of the recalled vehicles," the company said in a statement.

The affected vehicles were built in December 2009, with 3,460 of those sold in the United States, while 341 were exported to China.

The Detroit automaker said it will notify owners of the recalled SRX models and schedule an appointment for inspection with any necessary repairs to be performed free of charge.

_______________________________GALLERY_______________________________

Aston Martin Recalling over 1,000 U.S. Vehicles Over Safety Concerns

British sportscar maker Aston Martin has notified the National Highway Traffic Safety Administration (NHTSA) of a safety recall 1,090 DB9, V8 Vantage and DBS vehicles built between 2007 and 2008.

In a letter sent by Aston Martin to the NHTSA, the British carmaker reported that the camber bolt that holds the front bottom suspension arm was not made to specification and "could crank along its shank" (shaft).

According to the company, this would allow the lower control arm to move freely, affecting the driver's ability to steer, and thus increasing the risk of a crash. The letter went on to say that drivers may hear a metallic rattling sound if the lower control arm had loosened in such a fashion.

An Aston Martin spokesperson told Bloomberg news that the defect was detected through company testing, not through any customer complaints. He went on to say that the driver would still be able to steer, but may notice 'looser handling'.

To rectify the defect, dealers will replace the affected camber bolts free of charge. Aston Martin has notified the NHTSA that the safety recall will begin on or before October 18th of this year.

By Tristan Hankins

Source: NHTSA / Bloomberg

_______________________________GALLERY_______________________________

Tesla Recalls 439 Roadsters Over Potential Fire Hazard

Tesla Motors has initiated a voluntary safety recall on its battery-electric Roadster 2.0 and 2.5 models following the discovery of a potential fire hazard involving an auxiliary power cable.

The California-based automaker said it became aware of the problem after a single incident where an auxiliary cable "chafed against the edge of a carbon fiber panel in the vehicle causing a short, smoke and possible fire behind the right front headlamp of the vehicle."

The affected 12 volt auxiliary cable is located in the passenger wheel well behind the right headlight. It is part of a backup system that provides power to systems including the front and rear lights, turn signals and airbags in the event the primary 12 volt power system fails or drops below a certain threshold.

Tesla said it has assured owners of the 439 affected Roadsters that it is merely a precautionary measure and does not affect the main battery pack or power systems in any way. It also does not affect Roadster 1.5 models (vehicles with a VIN ending in 500 or before), as these vehicles do not have the 12 volt auxiliary cable installed.

Owners of the affected models are being notified by email and post, and can make an appointment for Tesla service staff to inspect the cable and install a protective sleeve to prevent any further incidents. This can be done at the owner's home or place of work and takes approximately one hour. The appropriate regulatory agencies have also been notified.

By Tristan Hankins

_______________________________GALLERY_______________________________